2001 Ford F-150 Clutch Master Cylinder/ Reservoir REMOVAL AND INSTALLATION
download Removal NOTE: When replacing clutch master cylinder (7A543), remove tubing from vehicle for bench bleeding procedure. 1. Disconnect the clutch master cylinder push rod from the clutch and...
View Article2006 Ford Freestyle Transmission Fluid Drain and Refill GENERAL PROCEDURES
download NOTICE: The use of any fluid other than what is recommended for this transmission will cause transmission damage. Draining 1. With the vehicle in NEUTRAL, position it on a hoist. For...
View Article2002 Saturn SL2 A/T – 2nd to 3rd Gear Shift Flare
download Automatic Transaxle 2-3 Shift Flare During First Minutes of Driving After Cold Soak (Perform Bulletin Procedure) Models: 2002 Saturn S-Series Vehicles with Automatic Transaxle (RPOs MP6, MP7)...
View Article2008 Accord V6 with M/T 2-Door Transmission Grinds When Shifting Into 3rd Gear
download SYMPTOM The 6-speed manual transmission grinds when shifting into 3rd gear, pops out of 3rd gear, or is hard to shift into 3rd gear. NOTE: These symptoms can be intermittent and sometimes more...
View Article2000 Ford F-Super Duty 250-550 Clutch Master Cylinder and Reservoir REMOVAL...
download Removal CAUTION: Remove the entire clutch hydraulic system from the vehicle as an assembly when installing a new clutch master cylinder assembly (7C522). 1. Disconnect the clutch hydraulic...
View Article2006 Ford Explorer Transmission Fluid Refill procedure
download Transmission Fluid Refill NOTICE: This procedure contains the air purge steps required to purge air from the cooling system. This procedure is NOT intended for use with the Transmission Fluid...
View ArticleSubaru Clutch Replacement Transmission Removal Procedures
download It may seem obvious, but the first step in the job is to disconnect the battery after recording the customer’s radio station presets. Even a manual transmission has a surprising number of...
View Article2006 Ford Crown Victoria Automatic Transaxle/ Transmission REMOVAL
download NOTICE: Whenever a transmission has been disassembled to install new parts, the transmission fluid cooler tubes must be cleaned and backflushed using a suitable torque converter/fluid cooler...
View Article2005–2006 Toyota Tacoma CLUTCH PEDAL SQUEAK NOISE
download Some customers may complain about a “squeak” or “creak” noise when depressing or releasing the clutch pedal. The clutch master cylinder clevis assembly has been improved to eliminate this...
View Article2003-2005 Chevrolet TrailBlazer Automatic Transmission/Torque Converter...
download Automatic Transmission/Torque Converter Clutch (TCC) Shudder, Water in Transmission (Repair Transmission and Replace Transmission Filler Tube, Level Indicator and Seal) Condition Some...
View Article